2021 Ford E 350 recalls

What's wrong: Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. The underside of the engine cover may have mispositioned insulation, allowing the cover to get excessively hot.

Risk: Direct and continuous contact with certain areas of engine cover surface in the passenger compartment may increase the risk of injury or burns to the skin of the driver or front seat passenger.

Free remedy: Ford will notify owners, and dealers will inspect the engine cover for gaps between the rubber seal and the insulation. If gaps are present, the dealer will install engine cover insulation patches in the right hand and left hand inner lower corners of the engine cover. The dealer will also update the powertrain calibration for heat management under elevated idle conditions should a vehicle be equipped with SEIC or BCP, free of charge. The recall began February 15, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S73.

What's wrong: Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).

Risk: Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (RSC) functionality. These scenarios increase the risk of a crash.

Free remedy: Ford will notify owners, and dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall began May 18, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S13.

What's wrong: Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.

Risk: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.

Free remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.

What's wrong: Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake Hydroboost unit may result in a sudden loss of power steering fluid.

Risk: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.

Free remedy: Dealers will inspect the connection between the power steering lines and the Hydroboost unit, and replace the power steering lines, as necessary, free of charge. Owner notification letters were mailed on March 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S08.

What's wrong: Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake hydroboost unit may result in a sudden loss of power steering fluid.

Risk: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.

Free remedy: Dealers will replace the power steering pressure line and the hydroboost jumper line, free of charge. Vehicles in this recall were previously recalled under 22V-089 and owners will need to have the new remedy completed even if their vehicle was remedied under the prior recall. Owner notification letters were mailed on June 21, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S07.

What's wrong: Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles that received an incomplete software update under recall 20V795. The engine cover may become excessively hot.

Risk: Direct contact with certain areas of engine cover surface in the passenger compartment may increase the risk of injury or burns to the skin of the driver or front seat passenger.

Free remedy: Dealers will update the powertrain calibration for heat management under elevated idle conditions, free of charge. Owner notification letters were mailed January 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 22, 2025.