2003 Peterbilt 320 recalls
Data from the U.S. National Highway Traffic Safety Administration (NHTSA). Recall repairs are free at an authorized dealer. Not every vehicle of this model is affected — check your own VIN.
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Campaign 04V378000 · Reported 02/08/2004 · PACCAR INCORPORATED
What's wrong: CERTAIN TRUCKS EQUIPPED WITH NEXGEN LIQUID NATURAL GAS (LNG) TANKS ARE BEING RECALLED. THE INTRODUCTION OF WATER INTO THE DISCHARGE SIDE OF BOTH THE PRIMARY AND SECONDARY RELIEF VALVES SIMULTANEOUSLY AND SUBSEQUENT FREEZING IN SERVICE CAN RENDER THE VALVES TEMPORARILY INOPERATIVE.
Risk: IF NOT INSPECTED THE RISK OF TANK OVER-PRESSURIZATION AND A CATASTROPHIC TANK RUPTURE CAN OCCUR, POTENTIALLY RESULTING IN SERIOUS INJURY OR DEATH.
Free remedy: NEXGEN WILL NOTIFY THE CUSTOMER, PERFORM AN INSPECTION, AND PROVIDE INSTRUCTIONS FOR ORDERING AND INSTALLING THE RETROFIT KIT. OWNERS SHOULD CONTACT NEXGEN AT 1-770-720-6780 OR PETERBILT AT 1-940-591-4201.
EXTERIOR LIGHTING:TURN SIGNAL
Campaign 19V452000 · Reported 14/06/2019 · PACCAR Incorporated
What's wrong: PACCAR Incorporated (PACCAR) is recalling certain 1990-2020 Peterbilt 320 and 520 vehicles built with specific amber rear turn signals. The turn signals may also light up with the stop/tail lights when the brakes are applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Rear Turn signals that illuminate at the same time as the brake lights may create confusion and impair the effectiveness of the brake lights, increasing the risk of a crash.
Free remedy: PACCAR will notify owners, and for trucks with rear amber lights, dealers will add a jumper harness between the chassis electrical harness and amber tail lights, free of charge. The recall began August 1, 2019. Owners may contact PACCAR customer service at 1-940-591-4220. PACCAR's number for this recall is 19PBC.
Need other work done on your Peterbilt?
Recalls go to the dealer — for everything else, find a trusted local shop.
Find a shop near me