2023 Chevrolet Malibu Fuse Box Diagram & Amperage

Quick Answer

The 2023 Chevrolet Malibu features three main fuse box locations: under the hood (engine compartment), inside the cabin on the passenger side kick panel, and in the trunk.

Under-Hood Fuse Block (Engine Compartment)

The under-hood fuse block is located in the engine compartment on the driver's side, near the battery. This fuse block typically houses fuses and relays for critical engine components, powertrain control, and some high-current accessories. Always consult the fuse box lid diagram for the most accurate information as configurations can vary slightly by trim level.

Common Relays in the Under-Hood Fuse Block:

• RL1: Fuel Pump Relay
• RL2: Starter Relay
• RL3: PCM/ECM Relay
• RL4: HVAC Blower Relay
• RL5: A/C Compressor Clutch Relay

Instrument Panel Fuse Block (Passenger Side Kick Panel)

This fuse block is located inside the cabin, typically behind a removable panel on the passenger side kick panel near the door. It primarily controls interior electrical components, infotainment, power accessories, and safety systems.

Common Relays in the Instrument Panel Fuse Block:

• RL1: Accessory Delay Relay
• RL2: Power Window Relay

Trunk Fuse Block

The trunk fuse block is typically located in the left or right side trim panel of the trunk. This fuse box generally handles electrical systems for rear-mounted components, such as tail lights, fuel door release, and potentially amplifiers or other trunk-specific accessories.

Common Relays in the Trunk Fuse Block:

• RL1: Rear Defogger Relay

How to Test a Fuse

If an electrical component in your 2023 Chevrolet Malibu stops working, a blown fuse is often the culprit. Testing a fuse is a straightforward process:

1. Locate the Fuse Box: Refer to the Quick Answer section above to find the correct fuse box for the malfunctioning component.
2. Identify the Suspect Fuse: Consult the fuse box diagram (usually printed on the inside of the fuse box cover) to find the fuse corresponding to the faulty circuit.
3. Visual Inspection: Many fuses have a clear plastic body. Look for a broken wire or a melted appearance inside the fuse. If it's dark or cloudy, the fuse is likely blown.
4. Use a Fuse Tester or Multimeter: For a more accurate test, remove the fuse and use a fuse tester or set your multimeter to the continuity setting. Touch the probes to the metal terminals on both ends of the fuse. If there is continuity (the tester lights up or the multimeter beeps), the fuse is good. If there is no continuity, the fuse is blown.
5. Replace with Correct Amperage: If the fuse is blown, replace it with a new fuse of the exact same amperage rating. Using a fuse with a higher amperage can cause severe electrical system damage or even a fire.

Common Blown Fuses on This Vehicle

While fuse issues can arise from various problems, some fuses tend to blow more commonly due to their circuit's demands or typical usage. If you experience a sudden electrical failure, these are good places to start your diagnostics after checking the related component's fuse location:

• Cigar Lighter/12V Power Outlets: These fuses (often 15A or 20A, located in the instrument panel fuse block) are frequently blown by improper use of accessories, overloading, or short circuits from faulty chargers or devices. If your phone charger or other accessories stop working, check these first.
• Radio/Infotainment System: A sudden loss of stereo functionality can often be traced back to a blown fuse (typically 10A or 15A, in the instrument panel fuse block). Sometimes, issues with aftermarket installations or even a momentary power surge can cause this.
• Blower Motor: If your climate control fan suddenly stops working on all speeds, the blower motor fuse (often 30A or 40A, in the under-hood fuse block) is a common suspect. A failing blower motor itself can draw too much current and cause the fuse to blow.
• Headlights: While less common for modern vehicles, a single headlight failure (not both) might indicate a blown fuse for that specific headlight circuit (typically 15A or 20A, in the under-hood fuse block). If both headlights fail, the issue is more likely a relay or a main power supply.

Always remember to check the visible legend on your 2023 Chevrolet Malibu's fuse box lid and in your owner's manual for the most accurate and up-to-date fuse assignments for your specific trim level.

Find a trusted shop on Repairius.