2023 Isuzu NQR Oil Capacity & Filter Guide

The 2023 Isuzu NQR takes 8.5 quarts of engine oil. This guide provides essential information for maintaining the oil in your 2023 Isuzu NQR, including capacity, recommended oil type, filter cross-references, and maintenance tips.

Quick Answer

• Oil Capacity: 8.5 quarts (8.0 liters)
• Recommended Oil Weight: 5W-30
• Oil Type Specification: CJ-4 or fresher (Isuzu usually recommends their own branded oil which meets or exceeds CJ-4 specifications. Consult your owner's manual for the most up-to-date recommendation).
• Oil Filter (OEM): 8-984400-98-0 (This is a common commercial Isuzu part number, always verify with your VIN)
• Oil Filter Cross-Reference:
  • Wix: 57922
  • Fram: CH11802
  • Mobil 1: M1C-251A

Capacity by Engine Option

The 2023 Isuzu NQR typically comes with one engine option in most markets, the 4HK1-TC 5.2L Diesel engine. Therefore, the oil capacity remains consistent.

Oil Change Interval

Maintaining a regular oil change schedule is crucial for the longevity of your Isuzu NQR's diesel engine. Always refer to your owner's manual for the most accurate and up-to-date service intervals, as they can vary based on operating conditions and region.

• Normal Duty: Typically every 10,000 miles or 12 months, whichever comes first.
• Severe Duty: For vehicles operating under heavy loads, frequent short trips, extensive idling, or in dusty conditions, the interval may be reduced to 5,000 miles or 6 months.

Drain Plug Torque

Properly torquing the drain plug prevents leaks and damage to the oil pan. Always use a new crush washer with each oil change.

• Drain Plug Torque: 33 foot-pounds (45 Nm).
• Crush Washer: Always replace the crush washer with a new one to ensure a proper seal and prevent leaks.

How to Change the Oil

Changing the oil on your 2023 Isuzu NQR requires proper tools and safety precautions. If you're unsure, it's best to consult a professional.

1. Preparation: Ensure the engine is warm but not hot. Park on a level surface, engage the parking brake, and block the wheels. Raise the front of the vehicle if necessary for access and support with jack stands.
2. Drain Oil: Place a suitable drain pan under the oil pan. Locate the drain plug, remove it, and allow all the old oil to drain completely. Be careful, as the oil will likely be hot.
3. Replace Drain Plug: Once drained, clean the drain plug, install a new crush washer, and reinstall the drain plug, tightening it to 33 ft-lbs (45 Nm).
4. Remove Oil Filter: Place the drain pan under the oil filter and unthread the old filter. Be prepared for some oil to spill. Ensure the old filter gasket is not stuck to the engine block.
5. Install New Oil Filter: Apply a thin coat of new oil to the gasket of the new oil filter. Thread the new filter into place by hand until snug, then tighten an additional 3/4 to 1 full turn, or as specified on the filter itself. Do not overtighten.
6. Add New Oil: Remove the oil filler cap and carefully pour in approximately 8 quarts of the recommended 5W-30 CJ-4 oil. Start the engine and let it run for a few minutes to circulate the new oil and check for leaks around the drain plug and filter.
7. Check Oil Level: Shut off the engine, wait a few minutes for the oil to settle, then check the oil level with the dipstick. Add more oil if necessary to reach the "full" mark. Do not overfill.

Common Issues / Tips

• Diesel Particulate Filter (DPF) / Diesel Exhaust Fluid (DEF): The 4HK1-TC engine utilizes a DPF and DEF system. Using the correct CJ-4 or newer low-ash oil is critical to prevent DPF clogging and ensure the longevity of the emission system. Incorrect oil can lead to costly repairs.
• Fuel Dilution: Diesel engines, especially those with DPF regeneration cycles, can be susceptible to fuel dilution in the engine oil. Adhering to severe duty oil change intervals if your driving conditions warrant it can help mitigate issues caused by diluted oil.
• Regular Fluid Checks: Beyond oil, regularly check all other fluids, including coolant, power steering fluid, and DEF levels, as part of routine maintenance for your commercial vehicle.
• Genuine Isuzu Parts: While aftermarket filters are available and listed here, Isuzu often recommends using genuine Isuzu parts for optimal performance and warranty compliance, especially for critical components like oil filters.

Need an oil change? Find a trusted shop on Repairius.